63-fuel pick-up line?

["Ernie Stepney" <stepney@xxxxxxxxx>]

Sounds like you may have a pinhole in the pickup tube in the tank. Had a
Merc. do the same stuff because of a tiny rust hole.

-----Original Message-----
From: mailing-list-owner@xxxxxxxxxxxxxxxx
[mailto:mailing-list-owner@xxxxxxxxxxxxxxxx] On Behalf Of Lambda
Imperial63
Sent: June 29, 2003 4:12 PM
To: mailing-list@xxxxxxxxxxxxxxxx
Subject: IML: 63-fuel pick-up line?


Here's the problem...

My 63 runs fine until the fuel gets below 1/2 tank....    then if it is 
going uphill it sputters and kicks like it is running out of fuel and
goes 
about 20 MPH top speed, but it doesn't stall.   Once it gets to the top
of 
the hill and levels out, it catches itself and runs fine again.   I
guess 
its a good thing I don't have very long hills in Atlanta!

Sitting in the garage, level, it starts and runs fine at all levels of
fuel 
capacity, even at 1/8 tank.

The fuel coming into the carb seems clean and the fuel filter is clean,
even 
after a few thousand miles.

I siphoned some fuel out of the bottom of the tanks and poured it
through a 
cloth filter and it looks clean with not obvious dirt particles.

My theory is that the fuel pickup tube inside the gas tank may have a 
perforation(s) in it, around the 1/2 tank level, and when I step on the
gas 
going uphill at that level of fuel, and need more fuel pumped into the
carb, 
it starts to suck air, and the engine gets just enough fuel to keep the
car 
running, but not able to go uphill without rebelling.

Any other ideas or any experiences with a similar problem?

If this is the problem....

Can I get the line out of the tank without dropping the tank, or should
I 
bite the bullet, drop the tank, and it cleaned and resealed, and fix the

line as well....  and maybe evening replace all the fuel lines while I'm
at 
it?

Where can I get a replacement for this fuel pickup line?

Thanks for any advice or guidance on how to do this.

Bob
63 Imperial Crown

_________________________________________________________________
The new MSN 8: smart spam protection and 2 months FREE*  
http://join.msn.com/?page=features/junkmail