Re: Removing heater box

Dennis

Sent from my iPad

On Apr 17, 2020, at 1:28 PM, Bill M <y1topbanana73@xxxxxxxxx> wrote:

I JUST did mine.

Sorry if you have done some of these, but here's my main steps...

First remove at least the passenger front seat. I'm personally getting to old to try and contort around it to get my head under the dash. Laying flat on my back on the floor is MUCH better.

If you have a console I'd remove it too. I've never been able to get my box out or back in without doing this.

There's a bracket holding the box to the dash on the passenger side of the radio.

You'll also need to unscrew the ground wire connection for the fan which is between the fan and the dash.

Then pull the wiring harness plug off the left side of the box near the heater control valve.

I took the vacuum lines of the pots and labeled them instead of trying to pull it off the controls

Hope this helps.

Bill M
65 Coronet 500 'vert http://goo.gl/6xUS1
73 Dart Sport, 05 Ram 2500 CTD, 4WD, QC, LB, Laramie
14 Avenger R/T, 15 Durango R/T, 21 Model T Depot Hack

On Fri, Apr 17, 2020 at 11:03 AM <62-65-mail-list-club@xxxxxxxxxxx> wrote:

Yes,good point Don. Those heater control plastic tips are brittle.

Anthony Powell; he is listed on
http://1962to1965mopar.ornocar.com/restoration-sources.html
in the "Cooling System & Heating & Air Conditioning" section.

I recall he was thinking of retiring. I don't think I ever got a message from him saying he retired though.

Thanks,
Gary H.

> -------Original Message-------
> From: Donald Gallimore
>
> One thing to remember - do not try to take the vacuum hoses off the
> controller - guaranteed to break the nibs off them and then you're
> screwed. There is (was?) a guy in Texas who does a wonderful job
> restoring them but note my (was?) - check for contact in the 62-65
> tech files.
65mopars?hl=en.

--
--
--
Please address private email -- email of interest to only one person -- directly to that person. That is, email your parts/car transactions and negotiations, as well as other personal messages, only to the intended recipient. Do not just press "reply" and send your email to everyone using the general '62-'65 Clubhouse public email address. This practice will protect your privacy, reduce the total volume of mail and fine-tune the content signal to Mopar topic. Thanks!

1962 to 1965 Mopar Clubhouse Discussion Guidelines:
http://www.1962to1965mopar.ornocar.org/mletiq.html and http://www.1962to1965mopar.ornocar.com/general_disclaimer.html.
--
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
http://groups.google.com/group/1962to1965mopars?hl=en.
---
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
To unsubscribe from this group and stop receiving emails from it, send an email to 1962to1965mopars+unsubscribe@xxxxxxxxxxxxxxxx.
To view this discussion on the web visit https://groups.google.com/d/msgid/1962to1965mopars/CANzadSFPBuJv3OCXPxbvFHN-mTV_5jt6hf5-QWiYhB3NZrx0_A%40mail.gmail.com.