Cleaning a Gas Tank

["'Larry Ashbaugh' via The 1962 to 1965 Mopar Mail List Clubhouse" <1962to1965mopars@xxxxxxxxxxxxxxxx>]

I have a couple cars that have sat for a couple years, including my 64 Barracuda.  The gas in it is rusty and has flakes in it.  I opted to replace the tank, sending unit, rubber "donut" seal into the tank and the rubber shield between the tank and floor.  Cost was little over a hundred dollars, so not bad.  The other car is my only non-Mopar car, a 73 Triumph TR-6, and the tank for that is somewhere in the $500-600 range,obscene, and just short of unobtanium prices for new reproductions.  Used ones have the same scale as mine, so I am thinking of cleaning and maybe sealing the current tank.

My plan would be to use gravel to loosen up the old rust (the old, shake, not stirred process), followed by a good dose of Muriatic Acid.  If anyone has used this method, and if so, what concentration of acid did you use?  What to look out for?

Also, if anyone has used any of the gas tank sealing products, I would appreciate your thoughts and opinions on what worked or did not work for you (who to consider and who to avoid).

Sorry for the non-Mopar specific question, but I have other Mopars waiting in the wings (mainly 57-59 Coronets) that will need the same process and the small TR-6 tank might be a good learning tool, as I am sure that Forward Look Mopar gas tanks are not falling from the trees these days.

Thanks,

Larry (Akron)

-- 
-- 
--
Please address private email -- email of interest to only one person -- directly to that person. That is, email your parts/car transactions and negotiations, as well as other personal messages, only to the intended recipient. Do not just press "reply" and send your email to everyone using the general '62-'65 Clubhouse public email address. This practice will protect your privacy, reduce the total volume of mail and fine-tune the content signal to Mopar topic. Thanks!
 
1962 to 1965 Mopar Clubhouse Discussion Guidelines:
http://www.1962to1965mopar.ornocar.org/mletiq.html and http://www.1962to1965mopar.ornocar.com/general_disclaimer.html.
-- 
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
http://groups.google.com/group/1962to1965mopars?hl=en.

--- 
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
To unsubscribe from this group and stop receiving emails from it, send an email to 1962to1965mopars+unsubscribe@xxxxxxxxxxxxxxxx.
For more options, visit https://groups.google.com/d/optout.